KOPPERS CO., INC. -- A-788 SPLASH ZONE CMPD,PART A,B (NEW FORM)  -- 8010-00N008374
<pre>=====================  Product Identification  =====================

Product ID:A-788 SPLASH ZONE CMPD,PART A,B (NEW FORM)
MSDS Date:01/01/1987
FSC:8010
NIIN:00N008374
=== Responsible Party ===
Company Name:KOPPERS CO., INC.
Emergency Phone Num:1-800-553-5631
CAGE:6V069
=== Contractor Identification ===
Company Name:KOPPERS CO INC BUILDING MATERIALS DIV
Address:KOPPERS BLDG
Box:City:PITTSBURGH
State:PA
ZIP:15219-1818
Country:US
CAGE:85663
Company Name:KOPPERS CO., INC.
Address:950 KOPPERS BLDG.
Box:City:PITTSBURGH
State:PA
ZIP:15219
Phone:(412) 227-2000
CAGE:6V069

=============  Composition/Information on Ingredients  =============

Ingred Name:EPOXY RESIN
Fraction by Wt: < 25%

Ingred Name:IRON OXIDE,AS FUME (CAS# 1309-37-1 (OSHA PEL=10 MG/CUM)
RTECS #:JN0740000
Fraction by Wt: < 5%
ACGIH TLV:5 MG(FE)/CUM

Ingred Name:TALC (CONTAINING NO ASBESTOS)
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: < 65%
OSHA PEL:2 MG/M3 RDUST
ACGIH TLV:2 MG/M3 RDUST; 9192

Ingred Name:2,4,6 TRIS(DIMETHYLAMINO)METHYL PHENOL (CAS# 90-72-2)(TLV
    RECOMND BY RAW MATL SUPPLIER)
CAS:90-72-2
RTECS #:SN3500000
Fraction by Wt: < 2%
ACGIH TLV:5 PPM

=====================  Hazards Identification  =====================

Effects of Overexposure:EYE:IRRIT,CORNEAL
    DMG.SKIN:IRRIT,DERMATITIS,SENSIT.INHAL:RESP TRACT IRRIT.IRON OXIDE
    (SEE SUPP DATA)

=======================  First Aid Measures  =======================

First Aid:EYE:FLUSH W/H*20 FOR 15 MIN.SKIN:WASH W/SOAP,H*20.WASH CONTAM
    CLTHG BEFORE REUSE.INHAL:RMV FROM EXP.IF NOT BRTHG/DIFF,GIVE ARTF
    RESP/O*2.INGEST:DONT INDUCE VOMIT.GIVE 1-2 GLASSES MILK.IN ALL
    CASES,CAL L DR.NO SPECIFIC ANTIDOTE FOR OVEREXP,TREAT SYMP.

=====================  Fire Fighting Measures  =====================

Flash Point:A:> 400F; B:> 3F
Extinguishing Media:DRY CHEM,CO*2,FOAM/H*20 SPRAY(H*20/FOAM MAY CAUSE
    FROTHING).
Fire Fighting Procedures:FULL-FACE SCBA,FULL PROT EQUIP.COOL FIRE EXP
    CNTNRS W/H*20.
Unusual Fire/Explosion Hazard:IF HEAT,TOXIC VAP/DECOMP PROD
    RELEASED,FORM FLAM/EXPLO MIX IN AIR.CLSD CNTNR MAY EXPLODE IF
    HEATED.

==================  Accidental Release Measures  ==================

Spill Release Procedures:STOP LEAK IF NO RISK.STAY UPWIND.SMALL
    SPILL:TAKE UP W/SAND OR OTHR NONCOMBUST ABSORBENT MATL.FLUSH AREA
    W/H*20.LGE SPILL:DIKE FOR LATER DISPOSAL.CONTAIN RUNOFF FROM FIRE
    CONTROL,DILUTION H*20.SPECIAL  PROC POSS REQUIRED TO RMV RESINS
    AFTERSPILLS.

======================	Handling and Storage  ======================

Handling and Storage Precautions:KEEP IN CLSD CNTNR IN COOL,WELL
    SHADED,DRY VENTED AREA.PROT FROM PHYSICAL DMG.READ MFR PRECAUT
    BEFORE USE.WASH AFTER USE.AVOID BRTHG VAP,MIST/FUME.
Other Precautions:AVOID SKIN/EYE CONTACT.USE EYE PROT IF WEAR CONTACT
    LENS.PROD IS 2 PART KIT,ANY MIX OF PART A + B HAS HAZ OF BOTH
    PARTS.PROD REFORMULATED FEB 1986. SPEC GRAVITY:A:1.8149;B:1.6827.
    DOP:8/86.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:NIOSH/MSHA APPROVED RESP PROT DEPENDING ON
    CONDITION OF USE.
Ventilation:GENL/LOCAL EXHAUST VENT.LOCAL EXH NECESS IN ENCLSD/CONF
    AREA
Protective Gloves:NEOPRENE
Eye Protection:CHEM GOGGLES + FACE SHLD
Other Protective Equipment:IMPERVIOUS HEAD/NECK
    COVER,APRON,JACKET,PANTS,COVERALL,BOOTS
Supplemental Safety and Health
FUME/DUST-PNEUMOCONIOSIS,PULM FUNCT CHANGE.TALC-TALCOSIS,PLEURAL
    THICKENG.COUGH,SHORT BREATH POSS.INGEST:NAUSEA,VOMIT,DIARRHEA.IF
    PRE-EXIST RESP SYS,SKIN/EYE PROB-GREATER ADVERSE HLTH EFT RISK

==================  Physical/Chemical Properties  ==================

Solubility in Water:INSOLUBLE
Appearance and Odor:VISCOUS PASTE;MIX GREEN(PART A YELLOW,PART B BLACK
Percent Volatiles by Volume:0

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CO +/OR C0*2,ALDEHYDES,NITROGEN OXIDES
    + OTHER ORGANICS.

====================  Disposal Considerations  ====================

Waste Disposal Methods:PRODUCT IS USEPA DEFINED EP TOXIC WASTE.DISPOSE
    OF AS EP TOXIC WASTE IAW LOCAL,STATE & FEDERAL REGULATIONS.PLACE IN
    TIGHTLY SEALED LABELED CNTNR.REPORT TO NATIONAL RESPONSE
    CENTER(800-424-8802) IF REL EASED INTO ENVIRONMENT (ONE POUND OR
    MORE).

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.